喷射比对汽-柴油双燃料压燃发动机燃烧及微粒排放特性的影响研究

段加全; 梁镇东; 韩令海; 宫艳峰; 解方喜; 李小平

doi:1001-2222.2023.06.006

车用发动机 >

2023 , Vol. 0 >Issue 6: 39 - 46

DOI: https://doi.org/1001-2222.2023.06.006

栏目

喷射比对汽-柴油双燃料压燃发动机燃烧及微粒排放特性的影响研究

段加全 ,
梁镇东 ,
韩令海 ,
宫艳峰 ,
解方喜 ,
李小平

展开

（1.中国第一汽车股份有限公司研发总院，吉林长春 130000;2.吉林大学汽车底盘集成与仿生全国重点实验室，吉林长春 130025;3.吉林大学汽车工程学院，吉林长春 130025）

收起

Effects of Injection Ratio on Combustion and Particulate Emission -Characteristics of Gasoline/Diesel Dual-Fuel Compression Ignition Engine

DUAN Jiaquan ,
LIANG Zhendong ,
HAN linghai ,
GONG Yanfeng ,
XIE Fangxi ,
LI Xiaoping

Expand

(1.China FAW Corporation R&D Institute,Changchun 130000,China;2.State Key Laboratory of Automobile Simulation and Control,Jilin University,Changchun 130025,China;3.College of Automotive Engineering,Jilin University,Changchun 130025,China)

Fold

摘要

在一台车用高压共轨增压柴油机上，基于均质混合气引燃（HCII）燃烧模式,采用进气道喷射汽油、缸内两段直喷柴油的双燃料部分预混的燃烧策略，探究了喷射比对不同负荷下汽柴油双燃料发动机的燃烧及排放的影响。结果表明：小负荷时，随着喷射比增加缸内压力和温度下降，燃烧恶化；中高负荷下较高的喷射比可以改善缸内燃烧过程，小幅度提高动力性和经济性；试验负荷下，随着喷射比的增加，NO_x排放降低；双燃料发动机较原机拥有更优的微粒排放特性，且随着喷射比的增加效果更加明显。

关键词： 喷射比; 均值混合气引燃（HCII）; 双燃料发动机; 颗粒

本文引用格式

段加全 , 梁镇东 , 韩令海 , 宫艳峰 , 解方喜 , 李小平 . 喷射比对汽-柴油双燃料压燃发动机燃烧及微粒排放特性的影响研究[J]. 车用发动机, 2023 , 0(6) : 39 -46 . DOI: 1001-2222.2023.06.006

Abstract

Based on the homogeneous charge induced ignition combustion mode, a dual-fuel partially premixed combustion strategy with gasoline injection in the intake port and diesel direct injection in two sections of the cylinder was adopted, and the effects of injection ratios on the combustion and emissions of gasolinediesel dual-fuel engine under different loads were investigated on an automotive high-pressure common-rail supercharged diesel engine. The results show that the pressure and temperature in the cylinder decrease and the combustion deteriorates with the increase of injection ratio under the small load. A higher injection ratio under medium and high loads can improve the combustion process in the cylinder, and slightly improve the power and economy. Under the test load, NO_x emissions reduce with the increase of injection ratio. Dual-fuel engines have better particulate emission charateristics than the original engine, and the effect is more pronounced as the injection ratio increases.

Key words： injection ratio; homogeneous charge induced ignition（HCII）；dual-fuel engine；particulate

Options

摘要页面

文章导航

模态框（Modal）标题

摘要

本文引用格式

Abstract